Importance of dust remover in pneumatic conveying process

對于袋式過濾器，其工作溫度取決于兩個因素。一個是過濾材料的溫度，二個是氣體溫度高于露點溫度。由于玻璃纖維過濾介質的選擇眾多，其使用溫度可以達到280°C。降低高于該溫度的溫度，并且升高低于露點溫度的溫度。對于袋式除塵器，使用溫度與除塵效率之間的關系不明顯。這不同于電除塵。對于電動集塵器，溫度變化會影響粉塵的比電阻并影響除塵效率。

For bag filters, the operating temperature depends on two factors. One is the temperature of the filter material, and the other is that the gas temperature is higher than the dew point temperature. Due to the numerous choices of glass fiber filter media, its use temperature can reach 280 ° C. Lower the temperature above this temperature and raise the temperature below the dew point temperature. For bag filter, the relationship between operating temperature and dust removal efficiency is not obvious. This is different from electrostatic precipitation. For electric dust collector, temperature change will affect the specific resistance of dust and the dust removal efficiency.

在氣力輸送設備的實際操作中，在大多數情況下，需要連續運輸，并且連續運輸會增加缺陷的發生率。為了減少出現缺陷的頻率，在使用過程中應注意一些注意事項。，我們了解，低壓輸送泵是由連續泵組成的低壓系統。該系統具有很高的可靠性，并且不能與任何其他運輸設備進行比較，因?yàn)樵撓到y(tǒng)大多數使用羅茨風扇。市場上的根源風扇的可靠性非常強，然后選擇功率傳輸系統的可靠性。但是，這種設備的類型和數量并不多，因此整個系統看起來非常簡單可靠，氣動輸送并且在連續運行下非常穩定，沒有任何沖擊載荷。因?yàn)樗幌癯Ｒ?guī)的動力傳輸過程那樣頻繁地操作閥門，所以可以減少缺點。

In the actual operation of pneumatic conveying equipment, continuous transportation is required in most cases, and continuous transportation will increase the occurrence rate of defects. In order to reduce the frequency of defects, some precautions should be taken during use. First of all, we understand that the low-pressure delivery pump is a low-pressure system composed of continuous pumps. The system has high reliability and cannot be compared with any other transport equipment, because most of the system uses Roots fans. The reliability of the root fan in the market is very strong, and then select the reliability of the power transmission system. However, there are not many types and quantities of such equipment, so the whole system looks very simple and reliable, pneumatic conveying is very stable under continuous operation, and there is no impact load. Because it does not operate the valve as frequently as the conventional power transmission process, the disadvantages can be reduced.

空氣量是除塵設備在單位時間內可以?xún)艋臍怏w量。單位是每小時立方米（m3/h）或標準立方米每小時（Nm3/h）。這是袋式過濾器設計中的重要因素。

Air volume is the amount of gas that can be purified by the dedusting equipment in unit time. The unit is cubic meter per hour (m3/h) or standard cubic meter per hour (Nm3/h). This is an important factor in bag filter design.

以上就是為大家介紹的有江蘇氣力輸送設備的詳細的介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以的態度,為您提供服務http://www.rohs-international.com

The above is a detailed introduction of Jiangsu pneumatic conveying equipment, and I hope it will be helpful to you. If you have any questions, please contact us. We will provide you with our attitude http://www.rohs-international.com